Technical Service Bulletins

2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-22: Information on OnStar Analog-Only Systems (06-08-64-007A)
2008-09-05: Information on Speedometer Accuracy (08-08-49-011B)
2008-07-16: Information on Aluminum Heater Core and/or Radiator Replacement (05-06-02-001A)
2008-06-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
2008-06-04: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
2008-05-30: Poor Radio Reception or Radio Static/Increased Interference with Rear Window Defogger On or Some Rear Window Defogger Grids May Be Inoperative (Diagnose and Repair Rear Window Defogger Heating Grid) (03-08-44-005H)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-15: Revised Cylinder Head Bolt Torque Specification and Tightening Sequence (02-06-01-003B)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-03-26: Additional Information About Passenger Presence Systems (PPS) - keywords bladder restraint seat sensor SIR system weight (PIT4138A)
2008-03-03: Class 2 Platform Battery Drain Diagnosis Purpose - keywords accessory aftermarket generator low operation regulator volt voltage (PIC4798)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-05: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013A)
2008-01-30: Remote Keyless Entry Operational Characteristics (99-08-52-005C)
2008-01-18: DEX-COOL Coolant - New Leak Detection Dye J 46366Replaces J 29545-6 (05-06-02-002B)
2007-12-05: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
2007-11-28: Procedure To Unlock Family Radio With Theftlock - keywords audio deterrent display entertainment inoperative loc lock theft theftdeterrent theftloc theftlock (PIC4696)
2007-11-06: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015)
2007-11-05: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001E)
2007-10-29: Revised General Motors New Vehicle Tire Warranty Program (00-03-10-003M)
2007-10-02: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
2007-09-18: ABS Pump Running When Not Needed - keywords unwanted (PIC4615)
2007-07-30: Usage of E85 Fuels in GM Vehicles (05-06-04-035C)
2007-06-22: Abnormal Noise And Or Vibration While Driving - keywords accessory aftermarket axle body boom buzz case grown growl howl moan modification no OEM part prop rattle resonance shaft transmission whine (PIP3140B)
2007-04-23: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (05-08-51-008B)
2007-04-09: No Power Steering Assist Shortly After Engine Ot Intake Camshaft Replacement - keywords adapter bushing damaged drive effort hard hex inoperative insert loose performance poor sleeve (PIP4099)
2007-03-09: Poor Radio Reception or Radio Static/Increased Interference with Rear Window Defogger On or Some Rear Window Defogger Grids May Be Inoperative (Diagnose and Repair Rear Window Defogger Heating Grid) (03-08-44-005G)
2007-03-01: Dexron VI Fluid Usage - keywords leak seal slip (PIP4066)
2007-02-01: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter (04-07-30-013B)
2007-01-24: KeyCode Security Rules and Information on GM KeyCode Look-Up Application (06-00-89-051A)
2007-01-17: Info - Hem Flange Rust Repair (02-08-98-002B)
2007-01-05: Slight Vehicle Movement In Park At Start Up After Cold Soak - keywords 3T40 4L60 4L60E 4L65E 4L80E 4L85E 4T40E 4T45E 4T60 4T60E 4T65E 4T80E 5L40E 5L50E 6L50 6L80 6L90 6T70 6T75 AF225 AF235aisan (PIP3763A)
2007-01-04: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance (01-03-10-012C)
2006-12-13: Information on OnStar Analog-Only Systems (06-08-46-007)
2006-11-28: Info - TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047G)
2006-10-30: Info - Exterior Lamp Condensation/Moisture/Water and Replacement Guidelines (01-08-42-001D)
2006-10-30: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032D)
2006-10-25: Info - Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013)
2006-10-18: Service Part Pump Cover Identification - keywords fluid leak pressure seal (PIP3946)
2006-10-10: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
2006-09-14: Info - GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits (05-00-89-078A)
2006-09-12: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
2006-08-22: Remote Keyless Entry Interference; Use of J43241 Fob Tester (PIT4105)
2006-08-11: Poor Acceleration from a Stop or Detonation in Gear at a Stop - keywords code DTC low MIL ping (PIP3144B)
2006-07-28: Info - Recreational (Dinghy) Towing (00-00-89-008F)
2006-06-27: Info - Timing Chain Tensioner Installation Procedure (00-06-01-010A)
2006-06-19: Info - Refinishing Aluminum Wheels (99-08-51-007C)
2006-06-12: Info - Promotional Pricing on Essential Tool Consumable Products (02-00-89-017B)
2006-06-08: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002D)
2006-05-24: No Movement Drive or Reverse - keywords 4T40E 4T45E cold converter delay engage fluid forward P0741 P0742 slip TCC pressure valve (PIP3253B)
2006-05-17: Info - Instructions to be Followed to Aid in Obtaining Root cause Analysis on Both OEM and Goodwrench Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
2006-05-02: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
2006-05-02: SPS Programming Concerns - keywords cluster communication DDM Door EBCM EBTCM engine gate HVAC IPC lift LGM module PCM PDM program SDM TBCM (PIT3418B)
2006-04-19: Information on Eliminating Noise in Audio System When using Portable Playback Device (06-08-44-015)
2006-04-13: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (05-03-10-003B)
2006-04-06: Discontinuation of the Field Product Reminder Bulletin/Bulletin Subscription Information (06-00-89-018)
2006-04-04: Information - Iridium and Platinum Tip Spark Plug Maintenance - keywords 30K major minor preventative removal remove replacement tune up (PIP3069C)
2006-03-29: Info - Vibration Analysis Worksheet (03-00-91-001C)
2006-03-29: Info - Urethane Adhesives for Stationary Glass and Other Applications (02-08-48-001B)
2006-03-02: Warranty Admin. - Labor Operation Assignments for All Control Module Reprogramming (02-06-04-057E)
2006-03-01: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
2006-02-17: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance (06-08-45-001)
2006-02-14: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004b)
2006-01-27: Service VME - Use Correct Engine Oil Drain Plug - keywords drain engine leak oil pan plug replace (PIP3696)
2006-01-24: Info - Expediting Warranty Parts (99-00-89-021E)
2006-01-18: Info - New Product Feedback Form and Process for Automatic Transmission Core Returns (01-07-30-029A)
2006-01-12: 4T65-E Automatic Transmission Fluid Leak from Reverse Servo Cover (Replace Reverse Servo Cover Seal) (04-07-30-028A)
2006-01-04: Info - Maintenance Cleaning of Fuel Injectors (04-06-04-051B)
2005-12-22: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
2005-11-21: Info - Paint-less Dent Repair Process (99-08-51-001A)
2005-11-16: Info - New PAG Oil Released (02-01-39-004B)
2005-10-06: Info - Transmission Fluid Leak Diagnosis (01-07-30-041B)
2005-09-23: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740,P0753,P0758,P0785,P0787,P0973,P0976,P1860,P2761,P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss (01-07-30-002E)
2005-09-08: Crank, No Start Due to Low Compression after Cylinder Head Repairs - keywords engine induced job machine mechnical shop (PIP3537)
2005-08-18: Info - Diagnosis of Cracked or Broken Transmission Case (02-07-30-024B)
2005-08-17: Info - Release of GM Tool Organizaiton DVD Version 8.0 (J-43921-G) (05-00-89-056)
2005-08-10: Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inop I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
2005-08-05: Info - SPAC Case Escalation Process (05-00-89-050)
2005-08-02: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case (05-04-21-004)
2005-06-28: Info - Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001B)
2005-06-27: Warranty Admin. - Out-Of-Warranty Parts for Engineering Analysis (05-00-89-037)
2005-06-23: Compensating for Different Axles Ratio and Tire Sizes with a VCI Number - keywords calibration ECM PCM pinion recalibrate reflash reprogram ring wheel TCSC techline (PIP3096B)
2005-06-08: Info - On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
2005-06-03: Goodwrench Powertrain Wholesale Program (U.S. Only) (05-06-01-017)
2005-05-12: Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
2005-05-03: Info - General Motors Dealership Critical Equipment Requirements and Recommendations (05-00-89-029)
2005-04-12: Info - Top Tether Hardware Package for Child Restraint Seats (99-09-40-004a)
2005-04-12: Info - OnStar System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
2005-03-21: Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
2005-03-17: Info - GM Parts Ordering System (05-00-89-018)
2005-03-08: Info - OnStar Kit Part Numbers and Compatibility (99-08-46-001A)
2005-02-09: Info - Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
2005-02-09: Info - Proper Air Bag System Diagnosis and Service (03-09-41-003A)
2005-01-31: Warranty Admin. - Guidelines for Claiming C0034 - Windshield Replacement (05-08-48-001)
2005-01-24: Info - Compact Disc (CD) or DVD Player Skipping, Inoperative, Sluggish and/or Long Search Times (05-08-44-001)
2005-01-14: Info - OnStar Proactive Parts Shipment Process (02-08-46-013A)
2005-01-07: All General Motors Passenger Cars, Trucks and Utilities Use of Star Washer on a Body or Chassis Ground - kw wire connector terminal starwasher star washer (PIT3353)
2004-12-13: Info - Battery Specification Label (04-06-03-016)
2004-12-10: No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022C)
2004-11-18: Info - Shipping Enhancements for Owners Manuals and Service Manuals Ordered from Helm, Inc. (04-00-89-057)
2004-11-18: Warranty Admin. - Warranty Return Parts (04-00-89-051)
2004-10-20: Info - Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
2004-10-11: Info - Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002A)
2004-10-08: Information on Error Codes on Radio Display - Their Cause and Corrective Action (01-08-44-005A)
2004-09-16: All 1995-2005 Passenger Cars and Trucks Information on Testing Centers for Fluid Contamination - kw brake coolant fluid fuel gasket gear hydraulic leak oil part porosity power seal specification (PIT3173)
2004-09-14: Info - Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (01-01-38-006D)
2004-09-10: All GM Vehicles Using Class 2 Communications Diagnostic Strategy for DTC U1000 or U1255 - kw BCM code EBTCM radio RIM (PIT3154)
2004-08-19: Odometer Accuracy - kw inaccurate cluster speedometer (PIC3100)
2004-08-03: Warranty Admin. - Dealer Installed Regular Production Options (RPO) and Regular Production Accessories (RPA) (01-00-89-015A)
2004-08-02: Info - Repair Procedure for Service Sheet Metal, Craters in ELPO Surface (04-08-98-002)
2004-07-27: Warranty Admin. - Changes to General Motors Vehicle Inquiry System (GMVIS) (04-00-89-029)
2004-07-27: Plastic Wheel Nut Covers Missing and/or Loose (Replace Missing Covers and Add Sealant to All Covers) (01-03-10-009A)
2004-07-02: Info - Battery Parasitic Drain (02-06-03-010A)
2004-06-22: Info - J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
2004-06-22: Info - New Owner Orientation Clinic Materials Now Available Online (03-00-89-002A)
2004-05-26: Info - Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
2004-04-29: Information on Serpentine Belt Wear (04-06-01-013)
2004-03-29: Warranty Administration - Part and Accessory Replacement Policy (04-00-89-011)
2004-03-18: No TCC Apply , MIL On , TCC Surge , Possible P0740 , P1870 , or 39 after Installation of Reman ( SRTA ) 4T60 / 4T60E - kw case cover converter slip transmission (PI01880A)
2004-02-11: Info - 4L65-E, 4L60-E, 4L60 and 200-4R Automatic Transmission Oil Pump Spring First and Second Design Identification (04-07-30-006)
2004-02-05: Warranty Admin. - Dealer Disclosure Requirements (02-00-89-005A)
2003-11-11: Info - Search Tips for Locating Preliminary Information (PI) Documents in Service Information (03-00-89-039)
2003-10-29: Diagnostic Information to Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
2003-09-19: Warranty Admin. - Sublet Administrative Allowance (Coverage: S) Labor Operations (03-00-89-027)
2003-07-14: Info - J 44551 A/C Suction Screen Kit Repair Recommendations and Procedures After Catastrophic Compressor Failures (01-01-39-003A)
2003-07-14: Info - HomeLink Transceiver/Garage Door Opener Transmitter Test Kit Available As Essential Tool (01-08-97-001B)
2003-06-25: Info - Most Frequently Asked Questions and Answers for J 45096 TransFlow Transmission Oil Cooling System Flushing Machine (03-07-30-027)
2003-04-29: Warranty Admin. - Courtesy Transportation Program (02-00-89-004B)
2003-04-24: Info - Bulletins Released Week of April 14, 2003 and Car and Truck Fix It Right the First Time Issues (03-00-89-010)
2003-03-17: Info - MN4 (4T40-E) MN5 (4T45-E) Engineering Changes (03-07-30-006)
2003-03-14: Info - Automatic Air Conditioning Control Operation (99-01-39-007B)
2003-03-07: Info - A/C Refrigerant System Sealer and A/C System Leak Detection Guidelines (03-01-38-001)
2003-03-07: Info - Changes to Essential and Available Tool Numbering System (03-00-89-005)
2003-02-27: Info - Powertrain Quality Center for Performance Parts Engine Replacements (03-06-01-006)
2003-01-30: Info - Polymer Service Pistons (01-06-01-010B)
2002-12-04: SMU - Revised Piston Pin Removal/Installation Procedures (01-06-01-002A)
2002-10-25: Proper Diagnostic Procedures for No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, SIR, Brake, Security, Theft, ABS, Hot, DIC Messages, Lamp, Light, Battery and Generator Diag. Testing (02-06-03-012)
2002-10-16: SMU - Revised Rocker Arm Bolt Fastener Tightening Specification (02-06-01-034)
2002-09-23: Product Safety - Ignition Circuit Thermal Events (02008B)
2002-09-23: Adm Msg - Important Programming/TIS Information for Technicians (Admin Number 20020120 - 9/10/02) (VSS20020120)
2002-08-09: Info - Engine Crankcase Flush (02-06-01-028)
2002-07-24: Info - U.S. On-Board Diagnostics (OBD) II Retrofit Program (02-06-04-039A)
2002-07-24: Warranty Admin. - Claim Procedures for Warrantable Electronic Failures on Vehicles Sold As Certified Used Vehicles or Certified Pre-Owned Vehicles (02-00-89-013)
2002-07-19: Warranty Admin. - Revised Empowerment Level-Authorization Code E (02-00-89-009)
2002-07-19: Info - Preliminary Information (PI) Text Available in Service Information (SI) (02-00-89-008)
2002-07-09: SMU-Revised DTC P0101 (02-06-04-040)
2002-06-21: Info - Expandable Acoustic Foam (Two Component Sound Dampener) Usage with Collision Damage Repairs (02-08-98-003)
2002-06-13: Info - Automatic Transmission Serial Number and Site Code Locations (02-07-30-028)
2002-06-13: Info - Engine Identification Information (02-06-01-026)
2002-04-11: SMU - Revised Lower Intake Manifold Installation (02-06-01-014)
2002-04-09: SMU - Revised Brake Specifications (02-05-22-001)
2002-02-27: Information on a New Engine Preluber Tool (02-06-01-008)
2001-12-18: Info - Tire Sidewall Damage (01-03-10-011)
2001-12-17: SMU - Revised Ignition Lock Cylinder or Ignition Switch Assembly Replacement (01-08-49-020)
2001-11-30: Water Pump Weep (Install Coolant Collector) (01-06-02-012)
2001-11-14: Info - Test Guidelines for Use of Essential Tool J41413-200 Evaporative System Tester (01-06-04-044)
2001-10-04: Info - Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
2001-09-17: Warranty Admin. - Correct Use of Labor Operation R4490, RKE Transmitter, Replace (01-00-89-013)
2001-08-24: Driveability Symptoms Due to Clogged Fuel Injectors (Clean Injectors) (99-06-04-005B)
2001-06-21: Info - Seat Belt System Replacement Guidelines for Vehicles Involved in Collisions (01-09-40-002)
2001-05-08: Info - Replacement of Keys, Key Numbers and/or Security Chips (01-00-89-009)
2001-04-09: Info - Guidelines for Use of Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
2001-04-06: Info - Current CIPS Campaign Number to Previous DIvisional Campaign Number (01-00-89-008)
2001-03-02: Info - February, 2001 Bulletin Summary (01-00-89-006)
2001-02-02: Info - January, 2001 Bulletin Summary (01-00-89-005)
2001-01-03: Info - December, 2000 Bulletin Summary (01-00-89-001)
2000-12-18: Warranty Admin. - January 1, 2001 Labor Time Guide Updates (00-00-89-031)
2000-12-06: Info - Water Pump Weep (Normal Condition) (00-06-02-009)
2000-12-04: Info - November, 2000 Bulletin Summary (00-00-89-030)
2000-11-13: Warranty Admin. - December, 2000 Labor TIme Guide Updates (00-00-89-029)
2000-11-02: Info - October. 2000 Bulletin Summary (00-00-89-028)
2000-10-24: Info - The Importance of Chassis Lubrication (00-00-90-001)
2000-10-17: Warranty Admin. - November, 2000 Labor Time Guide Updates (00-00-89-025)
2000-10-06: Info - September, 2000 Bulletin Summary (00-00-89-024)
2000-09-21: Info - Correct Diagnostic Procedure When Reviewing A/C Performance/Leak Suspected (00-01-38-007)
2000-09-19: Warranty Admin. - October, 2000 Labor Time Guide Updates (00-00-89-023)
2000-09-05: Information - August, 2000 Bulletin Summary (00-00-89-022)
2000-08-17: Warranty Admin. - Cross-line Warranty (00-00-89-021)
2000-08-14: Warranty Admin. - September, 2000 Labor Time Guide Updates (00-00-89-020)
2000-08-10: Warranty Admin. - New Electrical Relay Labor Operation Numbers (00-00-89-019)
2000-08-08: Info - July, 2000 Bulletin Summary (00-00-89-018)
2000-08-03: Info - Essential Tool J 43600 ACR 2000 (00-01-38-006)
2000-07-12: Warranty Administation - August, 2000 Labor Time Guide Updates (00-00-89-017)
2000-07-06: Information - June, 2000 Bulletin Summary (00-00-89-016)
2000-06-19: Warranty Admin. - July, 2000 Labor Time Guide Updates (00-00-89-014)
2000-06-19: Warranty Admin.- PCM Product Feedback Program (00-06-04-026)
2000-06-08: Info - California Consent Order on Settlement of Lawsuit on Batteries (Prop 65) (00-06-03-006)
2000-06-06: Info - May, 2000 Bulletin Summary (00-00-89-013)
2000-05-15: Info - Proper Service of Quick Connect EVAP System Connectors (00-06-04-021)
2000-05-12: Warranty Admin. - June, 2000 Labor TIme Guide Updates (00-00-89-012)
2000-05-08: Info - Brake Fluid Level and Filling Recommendations (00-05-22-004)
2000-04-14: Warranty Admin. - May, 2000 Labor Time Guide Updates (00-00-89-010)
2000-04-05: Snow Intrusion Into Rr Drum Brake Assem (Replace Rr Brake Assem Backing Plates) (00-05-24-001)
2000-04-04: Info - March, 2000 Bulletin Summary (00-00-89-007)
2000-02-23: Informational - January, 2000 Bulletin Summary (00-00-89-003)
2000-02-23: Warranty Admin - April, 2000 Labor Time Guide Updates (00-00-89-004)
2000-01-13: Info - Frontal SIR On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
1999-12-23: Info - Trap Resistant Rear Compartment (Trunk) Kit (99-08-66-002A)
1999-12-06: Info - The Year 2000 (Y2K) and Vehicle Electronics (99-00-89-022)
1999-10-26: Info - PCM Reprogramming (99-06-04-053)
1999-10-20: Info - Radiator Repair/Replacement Guidelines (99-06-02-017)
1999-10-14: November, 1999 Labor Time Guide Updates (99-00-89-020)
1999-10-08: Warranty Administration - October, 1999 Labor Time Guide Updates (99-00-89-017)
1999-08-10: Warranty Admin - September, 1999 Labor Time Guide Updates (99-00-89-016)
1999-07-29: Info - Compact Disc (CD) Players and Compatible CDs (99-08-44-006)
1999-07-28: Warranty Admin - August, 1999 Labor Time Guide Updates (99-00-89-012)
1999-07-23: Info - Vehicles Equipped with a Webasto Sunroof System (99-08-67-003)
1999-06-25: Warranty Admin - July 1999 Labor Time Guide Updates (99-00-89-010)
1999-05-25: Information - Original Equipment Chrome Plated Aluminum Wheel Identification (99-03-10-102)
1999-05-19: June 1999 Labor Time Guide Updates (99-00-89-008)
1999-04-20: Warranty Admin. - May, 1999 Labor Time Guide Update (99-00-89-006)
1999-04-06: Labor Time Guide Updates - April 1999 (99-00-89-004)
1999-03-31: Info - Cleaning of Upper Instrument Panel Surfac (99-08-49-006)
1999-03-09: Labor Time Guide Updates (99-00-89-003)
1999-03-04: Battery Insulator Replacement (99-06-03-002)
1999-02-26: Essential Tool J 42000 Battery Tester (99-06-03-001)
1999-02-19: Warranty Parts Center/Corporate Parts Return Program (40-05-01C)
1999-02-16: Warranty Administration - Labor Time Updates (99-00-89-001)
1998-11-16: INFO - ESSENTIAL TOOL J43435 ADJUSTER LOCKNUT (83-32-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-11-11: WARRANTY ADMIN. - LTG UPDATES (83-05-10)
1998-10-29: INFO - TEMP. CHANGES TO TECHLINE ESI APPLICATIONS (83-01-20)
1998-10-20: INFO - ESSENTIAL TOOL J43485 POWER STEERING BLEEDER ADAPTER (83-32-09)
1998-10-09: DOOR HANDLES ON WHITE PAINTED VEHICLES TURNING YELLOW (83-17-04)
1998-10-08: WARRANTY ADMIN - LTG UPDATES (83-05-09)
1998-10-01: INFO - NEW WINDSHIELD AND STATIONATY GLASS URETHANE (83-15-16)
1998-09-23: SQUEAK/SQUAWK TYPE NOISE WHILE STEERING (INSTALL RACK AND (83-32-08)
1998-09-17: WARRANTY ADMIN. - LTG UPDATES (83-05-08)
1998-09-16: INFO - NEW PCM CONNECTOR SERVICE KITS (83-81-32)
1998-09-16: SMU - SEC. 0B - CORRECTED CRANKCASE VENTILATION SYSTEM (83-02-01)
1998-08-31: SMU - SEC. 6 - ENG. MECHANICAL REVISED PISTON RING GAP, (87-61-30)
1998-08-21: WARRANTY ADMIN - LTG UPDATES (83-05-07)
1998-08-21: INFO - TOWING (16-01-01B)
1998-08-20: INFO - ESSENTIAL TOOL J-43241 REMOTE KEYLESS ENTRY AND (83-90-12)
1998-08-14: INFO - CORRECT LABOR CODE USAGE FOR ENTERTAINMENT SYS. (84-96-01)
1998-08-12: WARRANTY ADMIN. - REDEFINED USE OF PARTS WARRANTY SPECIAL (80-05-03)
1998-07-15: WARRANTY ADMIN. - LTG UPDATES (83-05-06)
1998-06-22: SMU - SECTION 6A - ENGINE MECHANICAL - TIMING CHAIN (67-61-22A)
1998-06-11: COLD ENGINE TICK OR RATTLE AFTER AFTER START-UP (57-61-24A)
1998-06-11: WARRANTY ADMIN. - LTG UPDATES (83-05-05)
1998-06-08: ENG. OIL ODOR (REPLACE REAR MAIN BEARING SEAL) (87-60-02A)
1998-06-05: WEAK OR DISCHARGED BATTERY, SLOW STARTING, GEN. OR MIL. ON (83-64-16)
1998-06-03: INFO - NEW TOOL J-42958, REV. CHARTS AND SCHEM. FOR CRUISE (83-90-08)
1998-06-01: INFO. ON TRANSAXLE COOLER LINE SEAL INSTALLATION PROC. (87-71-67)
1998-05-18: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-04)
1998-04-24: GENERAL MOTORS WARRANTY INQUIRY SYSTEM (82-05-05)
1998-04-21: WARRANTY ADMIN - REQ. FOR WHOLESALE AUTH. OR WARRANTY (82-05-02)
1998-04-16: WARRANTY ADMIN. - LTG UPDATES (83-05-03)
1998-04-14: SEAT BELT LATCH SLIDES TO SEAT BELT ANCHOR SLEEVE (73-16-16A)
1998-04-02: INFO. USE OF'SURFACE CONDITIONING DISCS' (87-61-24)
1998-03-25: WATER LEAKING INTO PASS. COMPARTMENT (APPLY RTV (73-10-68)
1998-03-16: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (83-05-02)
1998-03-10: INFO. NEW TOOL J-41450-B RELEASED FOR CS GEN DIAG. (83-64-09)
1998-03-02: INFO - FUEL LEVEL SENSOR REPLACEMENT PROC (83-83-07)
1998-03-01: ABS INDICATOR LAMP ON, DTC 21, 22, 32 OR 33 SET (63-50-15B)
1998-02-20: WARRANTY ADMIN - LABOR TIME GUIDE UPDATES (83-05-01)
1998-02-16: SMU- SEC. 7 - TRANS./TRANSAX. TRANSFER CASE UNIT REPAIR (77-71-79A)
1998-02-13: INFO. ON VIN PLATE REPLACEMENT (83-01-14)
1998-01-14: INFO. - DIAG PROC. WHEN A/C DIAG INFO LEAK (73-12-12A)
1998-01-12: INFO. FRONT. SUPP. INFLAT. RESTRAINTS (SIR) ON-OFF SWITCH (73-90-23)
1997-12-19: REAR BRAKES DRAG/HEAT UP (ADJUST BRAKE LAMP SWITCH (73-50-18)
1997-12-18: WARRANTY ADMIN. - REPAIR/ REPLACE POLICIES & PROC. (72-05-13)
1997-12-18: WARRANTY ADMIN. - ENHANCED SUBLET REPAIR POLICY (72-05-14)
1997-12-16: WARR. ADMIN - LABOR TIME GUIDE UPDATES (73-05-09)
1997-12-01: PAINT PEELING FROM MUFFLER (NEW REPAIR PAINT AVAILABLE) (33-17-01A)
1997-11-28: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (73-05-07)
1997-11-26: INFO. ON TECHNICAL ASSISTANCE CALL PREPARATION (73-01-10)
1997-11-20: CLARIFICATION OF RAIL DUST REM (A5575-A5580) (72-05-11)
1997-11-19: SQUAWK NOISE COMING FROM FRONT SUSPENSION (73-33-01A)
1997-11-18: INFO. ON INSTRUMENT CLUSTER IDENTIFICATION (78-83-03A)
1997-11-17: INOPERATIVE POWER DOOR LOCKS LOCKS WILL FUNCTION MANUALLY (63-10-41B)
1997-11-12: INFORMATION - PUREGUARD 2 OPERATING ALERT (73-12-13)
1997-11-10: REDUCING DISC BRAKE COME BACKS (NEW TOOL KIT & POLICY CHANGE) (23-50-05B)
1997-11-07: ENGINE STALL AT COLD START, ROUGH IDLE, OIL FILTER (77-61-09B)
1997-11-05: SQUEAK/SQUAWK NOISE COMING FROM BOTTOM OF STEERING COL. (73-32-09)
1997-11-01: WARRANTY ADMIN. - LABOR OPERATION CODE Z1241 (62-05-02A)
1997-10-24: WARR. ADMIN-LTG UPDATES 1989-98 PASS. CAR & TRUCK (73-05-06)
1997-10-17: INFO. ON COOLER FLUSH ADAPTER TOOLS FOR HYDRA-MATIC (77-71-68)
1997-09-25: INFO. NEW TUMBLERS FOR CYLINDERS RECODING REV. REPAIR (73-01-09)
1997-09-25: INFO - DIAG. HINTS FOR 'ROLLING CODE' REMOTE FUNC. (73-90-18)
1997-09-18: SMU-SEC.6E. ENG. CONT. REV. PCM OUTPUTS DIAG. TBL. (71-65-64)
1997-09-18: SMU-SEC. - 6E- ENG. CONT. REV. PCM CONT. GEN. TBL. (71-65-65)
1997-09-11: WARRANTY: TIRE REPLACEMENT DURING BUMPER TO BUMPER (70-05-01)
1997-09-01: INFO. ON ALUMINUM HEATER CORE AND/OR RADIATOR REPL. (73-62-13A)
1997-08-28: INFO. VARIOUS BRAKE NOISES WHEN APPLYING SRVC. BRAKE (73-50-25)
1997-08-21: WARRANTY ADMIN - GUIDELINES FOR USING E0420 WHEEL (72-05-05)
1997-08-21: WARRANTY ADMIN- GUIDELINES FOR USING I/M 240 LABOR OP (72-05-06)
1997-08-12: WARRRANTY ADMIN - LABOR TIME GUIDE UPDATES (73-05-05)
1997-08-01: DIFFICULT TO DEPRESS ACCELERATOR PEDAL (67-63-05A)
1997-07-23: SMU-SECTION 6A-ENG MECH BALANCE SHAFT (77-61-13)
1997-07-01: SMU - SECTION 0C - REVISED TIRE/WHEEL & PROPSHAFT (63-01-03A)
1997-07-01: CAMPAIGN: IGNITION LOCK CYLINDER BINDING (97038)
1997-06-19: SMU-SECTION 6E-REV. ENG CRANKS BUT DOES NOT RUN (71-65-45)
1997-06-18: SMU-SECTION 6E-REV KNOCK SENSOR NOISE (71-65-52)
1997-06-01: SMU-SECTION 6A -REV.PROC FOR INSTALL AND TORQUING (73-61-11)
1997-06-01: INFO. ON NEW AFTERMARKET PAINT SPECIFICATION (GM4901M) (63-17-07B)
1997-05-29: INFO ON AUTO TRANS OIL COOLER FLUSHING &FLOW CHECK PROC. (77-71-59)
1997-05-29: SMU-SECTION 6E-ENGINE CONTROLS REV. DTC P0502 -VEH SPEED SEN (71-65-49)
1997-05-21: WARRANTY ADMIN: LTG UPDATES 89-97 (73-05-04)
1997-05-16: FALSE DTC P0121 (REPROGRAM PCM) (77-65-14A)
1997-05-13: NO START CONDITION (REPROGRAM PCM) (77-65-16)
1997-05-12: INFORMATION -TWO PART URETHANE ADHESIVE (73-10-54)
1997-05-12: SMU-SECTION 8A-ELECTRICAL DIAGNOSIS - NEW DIAGNOSTIC (73-81-32)
1997-05-12: INFORMATION ON PRODUCTION SPARK PLUG GAP CHANGE (77-65-11A)
1997-05-01: SMU-SECTION 6 - ENG CONTROLS REVISED REFERENCE TO EVAP CONT (71-65-43)
1997-05-01: SMU - SECTION -6E - DRIVE AND EMISSIONS -REV. DTCP0705 (71-65-37)
1997-05-01: SMU - SECTIONS 3B/3C/4D - REVISED TIGHTENING SPECS. (73-32-03A)
1997-04-17: INFORMATION: FUEL GAUGE RESP. SLOWLY AFTER FUELING (73-83-15)
1997-04-17: INFO. ON A/C TOOL AND EQUIPMENT MAINTENANCE (63-12-08A)
1997-04-09: SMU - SECTION 6E - ENGINE CONTROLS - REVISED (71-65-38)
1997-04-04: SMU - SECTION 8E/8E1 REVISED CLEANING PROCDURE (73-82-03)
1997-04-01: CAMPAIGN: UNDERHOOD FUSEBLOCK COVER (97018)
1997-04-01: 1997 BILL 101 FRENCH LABEL INSTALLATION INSTRUCTIONS (35-01-04D)
1997-03-26: INFO. - REVISED SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) (73-01-07)
1997-03-24: INFORMATION ON WINDSHIELD REVEAL MOLDING (73-10-52)
1997-03-20: WARRANTY ADMINISTRATION - LABOR TIME GUIDE UPDATES (73-05-03)
1997-03-03: INFORMATION - SHIFT CABLE SERVICE CLIP (73-72-01)
1997-03-01: 'CLN' INDICATOR APPEARS ON RADIO DISPLAY (54-90-01A)
1997-02-20: WARRANTY ADMINISTRATION LABOR TIME GUIDE UPDATES (73-05-02)
1997-02-20: SMU - SECTION 7A - REVISED 4T40E FLUID LEVEL (63-71-06)
1997-02-12: DELAY ENGAGEMENT INTO DRIVE AFTER COLD SOAK (67-71-60)
1997-02-07: SERVICE ISSUES FOR VEHICLES WITH R12 OR R134A A/C SYSTEMS (73-12-04)
1997-02-05: INFO. ON PICTORIAL OF OXYGEN SENSOR DESIGNATIONS (67-65-40)
1997-01-31: INFO. NEW BODY SEALER TAPE FOR COLLISION REPAIRS (73-10-49)
1997-01-24: WARRANTY ADMINISTRATION - LABOR TIME GUIDE UPDATES (73-05-01)
1997-01-17: INTERMITTENT NEUTRAL OR LOSS OF DRIVE AT HIGHWAY SPEEDS (67-71-64)
1997-01-15: SMU - SECTION 6D1 - REVISED PARASITIC LOAD TEST (73-64-03)
1997-01-14: AIR COMING FROM I/P VENT WHILE IN HEATER MODES OR A DELAY (63-11-09)
1997-01-13: INFO. ON COMPACT DISC PLAYERS- PROCEDURES (64-96-01)
1997-01-08: LEFT REAR DOOR POWER WINDOW INTERMITTENTLY INOPERATIVE (63-10-51)
1997-01-07: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (63-05-07)
1997-01-07: SMU - SECTION 6E - ENGINE CONTROLS - REVISED (61-65-67)
1997-01-01: INSPECTION/MAINTENANCE PROCEDURE FOR RESTRICTED (63-50-19)
1996-12-20: INSTRUMENT PANEL CLUSTER SQUEAKS OR ITCH NOISE (63-83-13)
1996-12-05: SMU - SECTION 6E3 - DRIVEABILITY & EMISSIONS (61-65-58)
1996-12-03: WARRANTY ADMIN. - GM CERTIFIED USED VEHICLE WARRANTY REPAIRS (60-05-03)
1996-12-02: COOLANT LOSS, VISIBLE COOLANT LEAKAGE , LOW COOLANT LAMP ON (67-62-04)
1996-12-02: NO START CONDITION, GENERATOR MAY NOT BE CHARGING BATTERY (63-64-08)
1996-12-01: COLD START RATTLE NOISE (57-71-06A)
1996-11-25: SMU - SECTION 6E - ENGINE CONTROLS - CLEAR DTC'S (61-65-59)
1996-11-21: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES (63-05-06)
1996-11-15: INFO. REFERENCE CHART FOR A/C COMPRESSOR SEAL WASHERS (63-12-15)
1996-11-15: SMU - SECTION 6E3 - DRIVEABILITY & EMISSIONS (61-65-55)
1996-10-29: INFORMATION ON NEW PCM IDENTIFICATION LABEL (67-65-35)
1996-10-28: POPPING NOISE HEARD WITH MOVEMENT OF ENGINE (63-61-11)
1996-10-28: SMU - SECTION 8C1 - REVISED DIAGNOSTIC CHART # 7 (63-83-11)
1996-10-28: WARRANTY ADMIN. - GM TIRE WARRANTY POLICIES (60-05-02)
1996-10-25: INFO. ON COIL & IGNITION HOUSING CHARACTERISTIC (67-65-34)
1996-10-15: INFO. ON THE GENERAL MOTORS KEY CODE VOICE RESPONSE SYSTEM (61-01-11)
1996-10-14: SMU - SECTION 8A - 102 - REV. DIAGNOSTIC CHART #5 (63-81-34)
1996-10-10: WARRANTY ADMIN. - SUBMISSION OF ALL OBDII P - CODES (67-05-02)
1996-10-02: WARRANTY ADMIN. - LABOR TIME GUIDE UPDATES 1989 -1997 (63-05-04)
1996-10-01: PROCEDURE TO HANDLE CUSTOMER RADIO CONCERNS (68-96-01A)
1996-09-20: SMU - SECTION 1A - DELETION OF REFERENCE TO SPECIAL TOOL (63-11-12)
1996-09-11: DAYTIME RUNNING LAMPS REMAIN ON (63-81-26)
1996-09-01: SIR MODULE SHIPPING/RETURN PROCEDURES (31-90-04A)
1996-09-01: ACDELCO SERVICE CENTER LOC. FOR ODOMETER/SPEEDOMETER (66-83-04A)
1996-08-30: SMU - SECTION 6E - ENGINE CONTROLS - REVISED DTC P0121 (61-65-44)
1996-08-14: WARRANTY ADMIN. - LABOR TIME GUIDE ' REQUEST FOR REVIEW ' (63-05-03)
1996-08-06: SMU - SECTION 6E3 - DRIVEABILITY & EMISSIONS - REV (61-65-40)
1996-08-01: SMU - SEC. 6E3 - DRIVEABILITY & EMISSIONS - REVISED DTC (61-65-31A)
1996-06-28: SMU - SECTION 7A - AUTOMATIC TRANSMISSION / TRANSAXLE REV. (67-71-49)