Engine

All Component Locator

• Engine Controls Component Views

All Description and Operation

• Electronic Ignition (EI) System Description
• Evaporative Emission Control System Description
• Exhaust Gas Recirculation (EGR) System Description
• Fuel System Description
• Knock Sensor (KS) System Description
• Powertrain Control Module Description
• Throttle Actuator Control (TAC) System Description

All Special Tools and Equipment

• Special Tools

All Visual Identification

• Engine Controls Connector End Views
• Powertrain Control Module Connector End Views

Cleaning, Inspection, and Adjustment

• Fuel Injector Cleaning
• Fuel System Cleaning
• Spark Plug Inspection
• Spark Plug Wire Inspection

Diagnostic Procedures

• Alcohol/Contaminants-in-Fuel Diagnosis
• Backfire
• Crankshaft Position Sensor System Diagnosis
• Cuts Out, Misses
• Detonation/Spark Knock
• Diagnostic Starting Point - Engine Controls
• Dieseling, Run-On
• Electronic Ignition (EI) System Diagnosis
• Engine Cranks But Does Not Run
• Fuel Injector Balance Test with Special Tool
• Fuel Injector Balance Test with Tech 2
• Fuel Injector Solenoid Coil Test
• Fuel Pump Electrical Circuit Diagnosis
• Fuel System Diagnosis
• Fuel Tank Leak Test
• Hard Start
• Hesitation, Sag, Stumble
• Inspection/Maintenance (I/M) Catalyst System Set Procedure
• Inspection/Maintenance (I/M) Complete System Set Procedure
• Inspection/Maintenance (I/M) Exhaust Gas Recirculation (EGR) System Set Procedure
• Inspection/Maintenance (I/M) System Check
• Inspection/Maintenance (I/M) System DTC Table
• Inspection/Maintenance Evaporative Emission System Set
• Inspection/Maintenance Heated Oxygen Sensor Heater System Set
• Inspection/Maintenance Heated Oxygen Sensor/Oxygen Sensor System Set
• Intermittent Conditions
• Lack of Power, Sluggishness, or Sponginess
• Malfunction Indicator Lamp (MIL) Always On
• Malfunction Indicator Lamp (MIL) Inoperative
• Manifold Absolute Pressure Sensor Diagnosis
• Poor Fuel Economy
• Poor Fuel Fill Quality
• Powertrain Relay Diagnosis
• Rough, Unstable, or Incorrect Idle and Stalling
• Service Bay Test
• Surges/Chuggles
• Symptoms - Engine Controls

Diagnostic Trouble Codes

• DTC P0016
• DTC P0030
• DTC P0036
• DTC P0050
• DTC P0053
• DTC P0054
• DTC P0056
• DTC P0059
• DTC P0060
• DTC P0068
• DTC P0101
• DTC P0102
• DTC P0103
• DTC P0107
• DTC P0108
• DTC P0112
• DTC P0113
• DTC P0116
• DTC P0117
• DTC P0118
• DTC P0120
• DTC P0125
• DTC P0128
• DTC P0131
• DTC P0132
• DTC P0133
• DTC P0134
• DTC P0135
• DTC P0137
• DTC P0138
• DTC P0140
• DTC P0141
• DTC P0151
• DTC P0152
• DTC P0153
• DTC P0154
• DTC P0155
• DTC P0157
• DTC P0158
• DTC P0160
• DTC P0161
• DTC P0171
• DTC P0172
• DTC P0174
• DTC P0175
• DTC P0201, P0202, P0203, P0204, P0205, or P0206
• DTC P0220
• DTC P0230
• DTC P0300
• DTC P0315
• DTC P0325
• DTC P0327 or P0332
• DTC P0335
• DTC P0336
• DTC P0340
• DTC P0341
• DTC P0351, P0352, or P0353
• DTC P0401
• DTC P0403
• DTC P0404
• DTC P0405
• DTC P0406
• DTC P0420
• DTC P0430
• DTC P0442
• DTC P0443
• DTC P0446
• DTC P0449
• DTC P0451
• DTC P0452
• DTC P0453
• DTC P0454
• DTC P0455
• DTC P0496
• DTC P0506
• DTC P0507
• DTC P0601, P0602, P0603, P0604, P0605, P0606, P0607, P1600, P1621, P1627, P1680, P1681, P1683, or P2610
• DTC P0641
• DTC P0650
• DTC P0651
• DTC P0685
• DTC P1106
• DTC P1107
• DTC P1111
• DTC P1112
• DTC P1114
• DTC P1115
• DTC P1125
• DTC P1133
• DTC P1134
• DTC P1153
• DTC P1154
• DTC P1404
• DTC P1516
• DTC P1640
• DTC P1650
• DTC P1660
• DTC P2101
• DTC P2107
• DTC P2108
• DTC P2119
• DTC P2120
• DTC P2125
• DTC P2135
• DTC P2138
• DTC P2A00
• DTC P2A01
• DTC P2A03
• DTC P2A04
• DTC U0107

Electrical/Electronic Schematic Diagrams

• Engine Controls Schematic Icons
• Engine Controls Schematics

Electrical/Electronic Specifications

• Altitude Versus Barometric Pressure
• Diagnostic Trouble Code (DTC) Type Definitions
• Diagnostic Trouble Code (DTC) Types
• Ignition System Specifications
• Temperature Versus Resistance

Gas, Vacuum and Fluids Schematics and Diagrams

• Emission Hose Routing Diagram
• Evaporative Emissions Hose Routing Diagram
• Fuel Hose/Pipes Routing Diagram

General Diagnostic Information

• Scan Tool Data Definitions
• Scan Tool Data List
• Scan Tool Output Controls

Mechanical Specifications

• Fastener Tightening Specifications

Removal, Installation, and Replacement

• Accelerator Pedal Replacement
• Air Cleaner Assembly Replacement
• Air Cleaner Element Replacement
• Air Cleaner Inlet Duct Replacement
• Camshaft Position Sensor Replacement
• Crankshaft Position Sensor Replacement
• Crankshaft Position System Variation Learn
• Engine Coolant Temperature Sensor Replacement
• Evaporative Emission Canister Purge Solenoid Valve Replacement
• Evaporative Emission Canister Replacement
• Evaporative Emission Canister Vent Solenoid Valve Replacement
• Evaporative Emission Hoses/Pipes Replacement - Engine/Chassis
• Exhaust Gas Recirculation (EGR) System Cleaning
• Exhaust Gas Recirculation Pipe Replacement
• Exhaust Gas Recirculation Valve Replacement
• Filler Tube Replacement
• Fuel Hose/Pipes Replacement - Chassis
• Fuel Hose/Pipes Replacement - Engine Compartment
• Fuel Injection Fuel Rail Assembly Replacement
• Fuel Injector Replacement
• Fuel Level Sensor Replacement
• Fuel Pressure Gage Installation and Removal
• Fuel Pressure Relief
• Fuel Sender Assembly Replacement
• Fuel Tank Draining
• Fuel Tank Pressure Sensor Replacement
• Fuel Tank Replacement
• Heated Oxygen Sensor Replacement - Bank 1 Sensor 1
• Heated Oxygen Sensor Replacement - Bank 2 Sensor 1
• Heated Oxygen Sensor Replacement - Bank 2 Sensor 2
• Ignition Coil Replacement
• Ignition Control Module Replacement
• Knock Sensor Replacement
• Manifold Absolute Pressure Sensor Replacement
• Mass Airflow Sensor Replacement
• Metal Collar Quick Connect Fitting Service
• Plastic Collar Quick Connect Fitting Service
• Powertrain Control Module Replacement
• Spark Plug Replacement
• Spark Plug Wire Replacement
• Throttle Body Assembly Replacement