Technical Service Bulletins

2008-09-29: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement (02-07-30-029L)
2008-09-29: Check Trailer Wiring Message Displayed On DIC - keywords connector electric hydraulic ITBC IPC tow towing wire wiring (PIT4366B)
2008-09-29: Eliminating Unwanted Odors in Vehicles (00-00-89-027E)
2008-09-29: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
2008-09-29: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process -For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB,Audio, Display, Map Concerns (08-08-44-010D)
2008-09-26: Muffler Buzz During Vehicle Operation or Exhaust Popping/Snapping Noise When Vehicle is Hot, at Idle or Immediately After Vehicle is Shut Off (Replace Straps on Muffler Heat Shield) (07-06-05-001D)
2008-09-26: Odometer Servicing When The Odometer Cannot be Set to the Actual Mileage - keywords cluster ipc mile program (PIT4720)
2008-09-25: Updated Warranty and Goodwill Exchange Program for Electronic Products (08-08-44-029)
2008-09-25: PDI Manual Folding Mirror Inspection - keywords base crack cycle door driver excessive fold left loose move movement passenger pivot play right (PIT4716)
2008-09-23: Audio Volume Stuck In Loud Position - keywords inoperative navigation radio sound (PIT4034B)
2008-09-22: Electronic Exchange Program Changes (03-00-89-013D)
2008-09-19: Navigation Display And Hard Keys Inop/Frozen - keywords button CD disc DVD entertainment inoperative intermittent lock loss nav program radio receiver software street U3U UVB update (PIT4698B)
2008-09-19: Information Required Before Ordering A New OnStar VCIM For A DTC B1000 - keywords blue button communication message no noconnect operation (PIC4600A)
2008-09-18: Suspension Vibration Or Frame Beaming At 40-60 MPH (64-80KM/H) - keywords front rear shake shock spring tire (PIT3009J)
2008-09-18: DVD Navigation Update Program, AVN Software Update Discs and Ordering Information (06-08-44-012C)
2008-09-17: Audio From Left Front Speaker Only - keywords inoperative no sound volume (PIT4163C)
2008-09-17: GM Tire Warranty Program Claims Submission Changes (U.S. Only) (08-03-10-012)
2008-09-16: Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017A)
2008-09-16: Dome Lights Inoperative - keywords bulb console courtesy interior lamp lamps lens light overhead switch (PIT4195C)
2008-09-16: Bearing Or Metallic Grinding Sound While Operating In Auto 4HI Or 4LO Modes - keywords grind growl noise (PIP4146B)
2008-09-15: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including the Chevy Bowtie (06-08-111-004A)
2008-09-12: Tire Pressure Light Stays On (Reprogram RCDLR) (08-03-16-004)
2008-09-12: Cylinder Head Oil Leak Next to Intake Port 1, 2, 7, or 8 - keywords (PIP4477)
2008-09-12: Back Up Alarm Inoperative And Needs To Be Connected During PDI - keywords 8s3 connector disconnected inop reverse shift up wire (PIT4551A)
2008-09-12: Audio From Lef Front Speaker Only - keywords inoperative no sound volume (PIT4163B)
2008-09-12: BCM Failure After Windshield Wiper Operation - keywords ajar door dome driver dimmer flasher fog haul headlight head high hazard inop inoperative lamp light lock low not on off power park radio rap (PIT4696A)
2008-09-11: Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as Upsized to Original Equipment (05-03-10-005D)
2008-09-05: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses (02-08-42-001C)
2008-09-03: Catalytic Converter Break-In Information To Prevent DTCs P0420 And/Or P0430 - keywords 4.8 5.3 6.0 6.2 break low L59 L76 L92 L9H LC9 LFA LH6 LH8 LMF LMG LM7 LQ4 LQ9 LR4 LY2 LY5 LY6 P0300 P0301 (PIP3119G)
2008-08-29: Car and Truck Fix It Right the First Time Issues (08-00-89-029A)
2008-08-29: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. and Canada Only) (07-03-10-016C)
2008-08-28: GM Training - September 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-10-89-032)
2008-08-28: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) (08-08-44-028)
2008-08-27: New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-00-89-014E)
2008-08-27: Overhead Dome and/or Reading Lamp Inoperative with Push Button Switch (Replace Switch(es)) (08-08-42-004)
2008-08-26: Discontinuation of Printed GM VIN Cards (08-00-89-031)
2008-08-26: Identifying Aftermarket Engine and Transmission Calibrations Gas Powered Engines Only and Automatic Transmissions (08-06-04-033B)
2008-08-26: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs) (08-08-44-015A)
2008-08-26: SES Light and DTC P0230 (PIP4462)
2008-08-25: Repair Information for Reconnection of Rear Window Defroster Contact or Tab (03-08-48-006E)
2008-08-22: Navigation Radio Diagnostic Questionnaires for Warranty Exchanges Through PQC Parts Restriction Process (For Navigation Radios with AM, FM, XM, CD, DVD, NAV, GPS, MP3, USB, Audio, Display, Map, Noise) (08-08-44-010B)
2008-08-22: Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns (08-06-03-009)
2008-08-21: Information on Automatic Transmission Service Fast Learn Adapts (SFL) Characteristics (08-07-30-039)
2008-08-21: New Removeable / Re-attachable Window Label - keywords glass off on passenger peel side sticker (PIT4702)
2008-08-20: Flare And Or Harsh 2-3 Shifts - keywords bump delay second slip third (PIP4395B)
2008-08-19: Wipers Park In Wrong Location - keywords ajar door dome driver dimmer fog haul high inop inoperative lamp light lock low not on runoff power radio rap repeat signal shut speed stay switch turn tow (PIT4696)
2008-08-15: Information on XM NAV Traffic Coverage Areas (08-08-126-001)
2008-08-15: Unwanted Stability Activation and/or C0710 -keywords abs brake message tire wheel (PIT4322C)
2008-08-14: Fuel Gauge Fluctuation In Park Or Neutral - keywords gage inaccurate intermittent ip ipc (PIT3046E)
2008-08-14: Information on Aftermarket Device Interference with OnStar Diagnostic Services (08-08-46-004)
2008-08-14: Body Creak Noise When Entering And Exiting Vehicle - keywords acceleration brake center floor frame go pan rocking squeak stop suspension under (PIT4695)
2008-08-13: Reporting Navigation Map Concerns (PIT4367D)
2008-08-13: Memory Seat Recall Inoperative From Key Fob - keywords control door lock move power remote switch (PIT4194B)
2008-08-13: Power Window Inoperative After Start Up - keywords crank door down driver engine inop left loss motor operation passenger right stop switch up window (PIT4693)
2008-08-12: Navigation Disc Replacements For Service Repairs - keywords inoperative operation radio update (PIT4329E)
2008-08-11: Radio Displays LOCKED After SPS Programming (PIT4007D)
2008-08-11: Navigation System Gives Out Of The Way Directions - keywords address body denso direction disc DVD guidance inaccurate incorrect loss amp nav radio plan preference program receiver route software (PIT4369B)
2008-08-11: Unable To Reset Clock On Navigation Radio - keywords battery clock inop inoperative (PIT3830D)
2008-08-11: Navigation Radio Will Not Play DVD Audio Or DVD Video Discs - keywords CD inop inoperative (PIT4196B)
2008-08-11: Informaiton on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
2008-08-08: Information on Water or Ethylene Glycol in Transmission Oil (08-07-30-035)
2008-08-07: EI07082 - Power Steering Fluid Leaking From Power Steering Gear/Rack Assembly (Engineering Information) (07-02-32-002F)
2008-08-06: GM Accessories VPO/LPO Programs - Reimbursement for Dealer Labor (08-00-89-005B)
2008-08-06: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY (05-06-04-022E)
2008-08-05: Question Regarding Installation Of Dealer Installed Accessories (PIT3099E)
2008-08-01: OnStar Turn By Turn / TBT Feature Inoperative - keywords blue button calibration call cellular communication data digital navigation operation performance (PIC4801A)
2008-08-01: Unable To Program Replacement VCIM - keywords module ogen8 onstar programming service sps tech2 techline tis2web UE1 vs3bgen7 (PIC4944)
2008-07-31: Flare And/Or Harsh 2-3 Shifts - keywords bump delay second slip third (PIP4395A)
2008-07-31: GM Training - August 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-028)
2008-07-25: Additional Wheel Speed Sensor Diagnostics - keywords ABS brake C0035 C0040 C0045 C0050 C0245 DTC lamp light message MIL P0609 service system unwant (PIT4683)
2008-07-25: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 (05-03-08-002B)
2008-07-23: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information led no operation red (PIC3597F)
2008-07-23: OnStar Power Consumption - keywords battery digital discharge drain draw parasitic VCIM (PIC4935)
2008-07-22: Service Stability Lamp DTC C0561 - keywords ABS booster brake brakes code DIC EBCM EBTCM engine light message stabilitrak TCS VSES (PIT4169D)
2008-07-22: Unable To Communicate With The EBCM DTC U0121 - keywords ABS brake IPC lamp light program stabilitrak TCS (PIT4056C)
2008-07-22: Service Stability Lamp DTC C0710 - keywords ABS brake brakes C0455 C071000 C07105A code DIC EBCM EBTCM light message stabilitrak TCS VSES (PIT4225B)
2008-07-21: GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) - (This in not a Saturn STS Requirement) (08-00-89-027)
2008-07-21: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output (02-06-03-008D)
2008-07-18: Creak Noise At Door Over Bumps - keywords body drivers front left passenger pillar rear right striker (PIT4679)
2008-07-17: GM Training - July 2008 New Course Information (For U.S. Dealers and Aftermarket) (08-00-89-026)
2008-07-15: Water Leak At Drivers Floor - keywords brake cable cowl deploy deployment front hood ip left odor park pretensioner side sir under unwanted (PIT4678)
2008-07-14: Accessory Drive Belt/Serpentine Belt Noise, Chirp, Squeal or Squeak (Check Pulley Alignment and Replace Belt, If Necessary) (08-06-01-015)
2008-06-30: New Blue Tooth Option - keywords cell cellular module navigation on onstar phone radio star (PIT4670)
2008-06-27: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) (07-00-89-047B)
2008-06-27: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles (05-03-07-009B)
2008-06-27: Service Stability Lamp DTC C0131 - keywords abs brake light message (PIT4162E)
2008-06-26: Oil Leak At Turbocharger Air Intake Pipe - keywords 6.6 BQMI CAC charge clamp cooler crankcase diesel engine inlet LMM PCV positive rear seep seepage turbo valley ventilation (PIP4372B)
2008-06-24: ABS Traction Control And/Or Stabilitrak Lights On With No DTCs - keywords brake C0035 C0040 C0045 C0050 C0110 C0131 C0161 C0186 C0196 C0245 C0252 C0299 C0450 C0455 C0550 C0710 control EBCM IP IPC pump (PIT4665)
2008-06-24: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047H)
2008-06-24: GM Goodwrench Limited Lifetime Service Guarantee (03-00-89-003A)
2008-06-23: Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011)
2008-06-20: Information on Use of Customer Concern Verification Sheets, Comeback Prevention, GM Technical Assistance Information Form (TAC), Strategy Based Diagnostics (SBD), Intermittent Concerns, Diagnostics (01-00-89-010H)
2008-06-19: Shift Stabilization and Tow/Haul Mode Feature for Hydra-Matic 6L80/6L90 Automatic Transmissions (08-07-30-030)
2008-06-18: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement (08-08-44-023)
2008-06-18: TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004A)
2008-06-18: Enhancing Field Product Reports with Digital Pictures (07-00-89-036A)
2008-06-18: OnStar Voice Recognition Operation Issues - keywords information intermittent microphone performance voice (PIC3011E)
2008-06-18: Unable To Connect To OnStar Handsfree Calling Digital Hardware - keywords cellt cellular communication droppedcall failedtovoice information intermittent OPC operation no noconnect performance region (PIC4310C)
2008-06-17: EI07082 - Power Steering Fluid Leaking from Power Steering Gear/Rack Assembly (Engineering Information) (07-02-32-002E)
2008-06-17: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy (05-00-89-072B)
2008-06-13: Information on Inspection Top Post Battery Cable Bolts, Clamps and Nuts During Pre-Delivery Inspection (PDI) (07-06-03-002B)
2008-06-06: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE (99-04-20-002E)
2008-06-05: OnStar Deactivated Returned To Stock New Vehicle Inventory - keywords activation button deactivated disabled inventory keypress letter (PIC4889)
2008-05-30: GM Accessory Tonneau Cover Twist Lock Hande Binds - keywords accessories bed body broken cover rear (PIT4655)
2008-05-30: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. Only) (07-03-10-016A)
2008-05-30: Identifying Aftermarket Engine Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L 6.2L 7.0L, 7.4L, 8.1L Gas (08-06-04-033)
2008-05-30: Intermittent, Current or History DTC B2476 in Onstar GEN 6 or 7 VCIM - keywords blue button call communication data digital information keypad led OPC operation red (PIC4574B)
2008-05-29: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory (08-06-03-005)
2008-05-22: IPC Odometer Programming Method Quick Reference Guide (07-08-49-020B)
2008-05-22: Information on Slight Vehicle Movement in Park at Start Up After Cold Soak (08-07-30-026)
2008-05-22: Bearing or Metallic Grinding Sound While Operating In Auto, 4HI or 4LO Modes - keywords grind growl noise (PIP4146A)
2008-05-16: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
2008-05-12: Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
2008-05-12: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
2008-05-08: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036E)
2008-05-08: TPM Sensor Programming Or Operation Issues - keywords accessories accessory learn pressure program programming rim sensor tire TPM wheel (PIT4644)
2008-05-07: Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Intrument Panel Clusters (IPC) (08-08-44-015)
2008-05-06: Disc Brake Warranty Service and Procedures (00-05-22-002K)
2008-05-02: Manual Transmission Operating Characteristics (03-07-29-004E)
2008-05-02: Required Return Criteria of Complete Electrical Centers (EC) and Body Control Modules (IBCMs) with Integrated Electrical Centers to Warranty Parts Center (WPC) (05-08-45-002D)
2008-05-02: Exterior Lamp Condensation and Replacement Guidelines (01-08-42-001F)
2008-05-01: GM Accessories Wheel Appearance Standards - keywords accessory aesthetics blister chrome ding dent dust peel rim wheel (PIT4636)
2008-05-01: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005)
2008-05-01: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) (08-03-10-006)
2008-05-01: Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
2008-04-30: ACDelco Replacement Battery Warranty Procedures (03-06-03-003B)
2008-04-29: Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
2008-04-28: Information on Paint Stain Under Protective Shipping Film (05-08-51-001C)
2008-04-18: Service Stability Lamp DTC C0131- keywords ABS brake light message service stability (PIT4162D)
2008-04-18: Information for Dealers on How to Submit a Field Product Report (02-00-89-002G)
2008-04-18: Onstar TBT (Turn by Turn) and Digit Dispays Location keywords call cellular comunication data digit digital hud information operation radio unable turn use (PIC4510A)
2008-04-17: Being Prepared for TAC, Caller Preparedness - Contacting U.S. Technical Assistance (TAC) and Use of Strategy Based Diagnostics (08-00-89-014)
2008-04-17: Electronic Exchange Program Goodwill Procedures (05-00-89-045A)
2008-04-17: Key Code Information (99-00-89-011C)
2008-04-17: Battery and Charging System Electrical Diagnostics (05-06-03-002C)
2008-04-16: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines (05-08-44-024A)
2008-04-14: Disabled OnStar System Identification - keywords blue button communication deactivated digital disabled information LED no operation red (PIC3597E)
2008-04-14: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts (00-06-01-012C)
2008-04-10: Handsfree Calling Inop With Demo Message On OnStar Keypress - keywords 05-08-46-006N blue button communication digital disabled message no OPC operation vs3bgen6 vs3bgen7 (PIC4564A)
2008-04-08: OnStar RPO Code Questions - keywords data digital information no option print (PIC4483A)
2008-04-07: General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015A)
2008-04-01: Warranty Claims Submission - Importance of GM Part Numbers and Parts with Date Codes (06-00-89-054B)
2008-03-27: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008)
2008-03-25: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories (08-03-10-004)
2008-03-14: Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002A)
2008-03-12: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation (08-08-51-002)
2008-03-12: Vehicle Battery Maintenance While in Dealer Stock (05-06-03-007A)
2008-02-27: Odometer Accuracy - keywords IPC speedometer (PIC3100B)
2008-02-07: GM of Canada New Vehicle Limited Warranty Tire Program (01-03-10-003E)
2008-02-06: Service Stability Lamp DTC C0131 - keywords ABS brake light message (PIT4162C)
2008-01-25: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006B)
2008-01-24: Under Hood Insulator Removed - keywords body build built engine missing noise paint sealer sound (PIT4564)
2008-01-17: Engineering Information (EI) Process (04-00-89-053B)
2008-01-10: Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029D)