Engine

All Component Locator

• Engine Controls Component Views

All Description and Operation

• Air Intake System Description
• Fuel System Description
• Glow Plug System Description
• Powertrain Control Module Description
• Service Programming System (SPS) Description

All Special Tools and Equipment

• Special Tools

All Visual Identification

• Engine Controls Connector End Views
• Powertrain Control Module Connector End Views

Cleaning, Inspection, and Adjustment

• Fuel Injection Pump Timing Adjustment
• Fuel Injection Pump Top Dead Center Offset Adjustment
• Fuel System Cleaning
• Water-in-Fuel Draining

Diagnostic Procedures

• Contaminants-in-Fuel Diagnosis
• Cuts Out, Misses
• Diagnostic Starting Point - Engine Controls
• Diagnostic System Check - Engine Controls
• Engine Cranks But Does Not Run
• Excessive Smoke
• Fuel Heater Inoperative
• Fuel Injection Nozzle Diagnosis
• Fuel Knock/Combustion Noise
• Fuel Pump Electrical Circuit Diagnosis
• Fuel System Diagnosis
• Fuel Tank Leak Test
• Glow Plug System Diagnosis
• Hard Start
• Hesitation, Sag, Stumble
• Inspection/Maintenance (I/M) Complete System Set Procedure
• Inspection/Maintenance (I/M) Component Monitoring System Set Procedure
• Inspection/Maintenance (I/M) Misfire Monitoring System Set Procedure
• Inspection/Maintenance (I/M) System Check
• Inspection/Maintenance (I/M) System DTC Table
• Intermittent Conditions
• Lack of Power, Sluggishness, or Sponginess
• Poor Fuel Economy
• Surges/Chuggles
• Symptoms - Engine Controls
• Water-in-Fuel Lamp Always On
• Water-in-Fuel Lamp Inoperative

Diagnostic Trouble Codes

• Diagnostic Trouble Code (DTC) List
• DTC P0112
• DTC P0113
• DTC P0117
• DTC P0118
• DTC P0121
• DTC P0122
• DTC P0123
• DTC P0126
• DTC P0182
• DTC P0183
• DTC P0215
• DTC P0216
• DTC P0219
• DTC P0220
• DTC P0221
• DTC P0222
• DTC P0223
• DTC P0225
• DTC P0226
• DTC P0227
• DTC P0228
• DTC P0231
• DTC P0236
• DTC P0237
• DTC P0238
• DTC P0251
• DTC P0263, P0266, P0269, P0272, P0275, P0278, P0281, or P0284
• DTC P0300
• DTC P0301-P0308
• DTC P0335
• DTC P0370
• DTC P0380
• DTC P0601, P0602, P0603, P0604, P0605, P0606, P0607, P1600, P1621, P1627, P1680, P1681, P1683, or P2610
• DTC P1125
• DTC P1214
• DTC P1216
• DTC P1217
• DTC P1218
• DTC P1627
• DTC P1635
• DTC P1641
• DTC P1643
• DTC P1654
• DTC P1656

Electrical/Electronic Schematic Diagrams

• Engine Controls Schematic Icons
• Engine Controls Schematics

Electrical/Electronic Specifications

• Diagnostic Trouble Code (DTC) Type Definitions
• Diagnostic Trouble Code (DTC) Types
• Engine Speed Versus Hertz (Hz)
• Temperature Versus Resistance

Gas, Vacuum and Fluids Schematics and Diagrams

• Emission Hose Routing Diagram
• Fuel Injection Line Routing Diagram

General Diagnostic Information

• Scan Tool Data Definitions
• Scan Tool Data List

Mechanical Specifications

• Fastener Tightening Specifications

Other Specifications

• Fuel System Specifications
• GM SPO Group Numbers

Removal, Installation, and Replacement

• Accelerator Pedal Position Sensor Replacement
• Air Cleaner Assembly Replacement
• Air Cleaner Element Replacement
• Boost Sensor Replacement
• Crankshaft Position Sensor Replacement
• Engine Coolant Temperature Sensor Replacement
• Engine Shutdown Solenoid Replacement
• Fuel Feed Pipe and Return Pipe Purging
• Fuel Filter Assembly Replacement
• Fuel Filter Replacement
• Fuel Heater Replacement
• Fuel Injection Line Replacement
• Fuel Injection Pump Replacement
• Fuel Injector Replacement
• Fuel Pump Replacement
• Fuel Sender Assembly Replacement
• Fuel Solenoid Driver Replacement
• Fuel Tank Draining
• Fuel Tank Replacement
• Glow Plug Relay Replacement
• Glow Plug Replacement - Bank 1
• Glow Plug Replacement - Bank 2
• Glow Plug System Relearn
• Intake Air Temperature Sensor Replacement
• Plastic Collar Quick Connect Fitting Service
• Powertrain Control Module Programming
• Powertrain Control Module Replacement
• Wastegate Actuator Replacement
• Wastegate Solenoid Replacement
• Water in Fuel Indicator Sensor Replacement