GM Service Manual Online
For 1990-2009 cars only
Makes 🢒 Chevrolet 🢒 2001 🢒 Corvette 🢒 Restraints 🢒 SIR 🢒 Inflatable Restraint Steering Wheel Module Coil Disassemble - Off Vehicle

Inflatable Restraint Steering Wheel Module Coil Disassemble - Off Vehicle Non-Telescoping Column


    Object Number: 323835 Size: SH

    Caution: This vehicle is equipped with a Supplemental Inflatable Restraint (SIR) System. Failure to follow the correct procedure could cause the following conditions:

       • Air bag deployment
       • Personal injury
       • Unnecessary SIR system repairs
    In order to avoid the above conditions, observe the following guidelines:
       • Refer to SIR Component Views in order to determine if you are performing service on or near the SIR components or the SIR wiring.
       • If you are performing service on or near the SIR components or the SIR wiring, disable the SIR system. Refer to Disabling the SIR System.

  1. Disable the inflatable restraint steering wheel module. Refer to Disabling the SIR System in SIR.
  2. Remove the upper and lower trim covers. Refer to Steering Column Trim Covers - Disassemble - Off Vehicle .
  3. Remove the wire harness straps (2) from the steering column tilt head assembly (1).

    4. Object Number: 323836 Size: SH
  4. Pop the wire harness assembly (1) from the wire harness strap (2).
  5. Disconnect the inflatable restraint steering wheel module coil connector.

    6. Object Number: 415291 Size: SH
  6. Remove the retaining ring (3) using snap ring pliers.
  7. Remove the inflatable restraint steering wheel module coil (4) from the steering shaft assembly (2).

Inflatable Restraint Steering Wheel Module Coil Disassemble - Off Vehicle Telescoping Column


    Object Number: 415291 Size: SH

    Caution: This vehicle is equipped with a Supplemental Inflatable Restraint (SIR) System. Failure to follow the correct procedure could cause the following conditions:

       • Air bag deployment
       • Personal injury
       • Unnecessary SIR system repairs
    In order to avoid the above conditions, observe the following guidelines:
       • Refer to SIR Component Views in order to determine if you are performing service on or near the SIR components or the SIR wiring.
       • If you are performing service on or near the SIR components or the SIR wiring, disable the SIR system. Refer to Disabling the SIR System.

  1. Disable the inflatable restraint steering wheel module. Refer to Disabling the SIR System in SIR.
  2. Remove the upper and lower trim covers. Refer to Steering Column Trim Covers - Disassemble - Off Vehicle .
  3. Remove the retaining ring (3) using snap ring pliers.
  4. Remove the inflatable restraint steering wheel module coil (4) from the steering shaft assembly (2).